Product ID:4817N THICK FILM COMPOSITION
MSDS Date:01/11/1992
FSC:8030
NIIN:00-919-9204
MSDS Number: BVFXZ

DU PONT E I DE NEMOURS & CO INC

1007 MARKET STREET
WILMINGTON, DE 19898
US

Emergency Phone: 800-441-3637/800-424-9300(CHEMTREC)

Info Phone: 800-441-7515/MSDS 302-992-3511

Cage: 18873

E.I. DUPONT DE NEMOURS & CO

WILMINGTON, DE 19898 US

Telephone: 800-441-7515;800-441-9442

Cage: 18873

PROPYLENE GLYCOL MONOMETHYL ETHER ACETATE

CAS: 108-65-6

RTECS: AI8295000

Fraction By Weight: 10-30%

OSHA PEL 100 PPM

ACGIH TLV: 100 PPN

N-BUTYL ACETATE (SARA III)

CAS: 123-86-4

RTECS: AF7350000

Fraction By Weight: 10-30%

OSHA PEL 150 PPM

ACGIH TLV: 150 PPM/200STEL;9394

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

DIBUTYL PHTHALATE (SARA III)

CAS: 84-74-2

RTECS: TI0875000

Fraction By Weight: 1-5%

OSHA PEL 5 MG/M3

ACGIH TLV: 5 MG/M3; 9394

EPA Report Quantity: 10 LBS

DOT Report Quantity: 10 LBS

AMINE COMPOUND

Fraction By Weight: <0.1%

SILVER (SARA III)

CAS: 7440-22-4

RTECS: VW3500000

Fraction By Weight: 30-60%

OSHA PEL 0.01 MG/M3

ACGIH TLV: 0.1 MG/M3; 9394

EPA Report Quantity: 1 LB

DOT Report Quantity: 1 LB

FATTY ACID DERIVATIVE

Fraction By Weight: 0.1-1%

ACRYLIC RESINS

Fraction By Weight: 10-30%

OSHA PEL 1 MG/M3

ACGIH TLV: 1 MG/M3

Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:SILVER: HUMAN EFFECTS OF HIGHER LEVEL
ACUTE OR CHRONIC OVEREXPOSURE MAY INCLUDE; ARGYRIA. ACRYLIC RESIN:
HUMAN HEALTH EFFECTS OF OVEREXPOSURE MAY INCLUDE; SKIN IRRITATION
WITH DISCOMFORT OR RASH, EYE IRRITATION WITH DISCOMFORT.
Explanation of Carcinogenicity:NO INGREDIENTS OF THIS PRODUCT ARE
DESIGNATED BY IARC, NTP, OSHA ACGIH OR DUPONT AS POTEBTIAL
CARCINOGENS.
Effects of Overexposure:ACRYLIC RESIN: TEARING OR BLURRED VISION,
NAUSEA, HEADACHE OR WEAKNESS. IRRITTION OF THE UPPER RESPIRATORY
PASSAGE.
Medical Cond Aggravated by Exposure:SKIN; LIVER; KIDNEY; CENTRAL
NERVOUS SYSTEM.

First Aid:SKIN-IMMEDIATELY FLUSH SKIN WITH WATER FOR 15 MIN WHILE
REMOVING CONTAMINATED CLOTHING/SHOES. CALL A PHYSICIAN.
EYE-IMMEDIATELY FLUSH EYES WITH WATER FOR 15 MIN. CALL A PHYSICIAN.
INHALATION-REMOVE TO FRESH AIR IMMEDIATELY. IF NOT BREATHIG, GIVE
ARTIFICIAL RESPIRATION. IF BREATHING IS HARD, GIVE OXYGEN. CALL A
PHYSICIAN. INGESTION-DO NOT INDUCE VOMITING. QUICKLY GIVE 2 GLASSES
OF WATER. CALL DOC.

Flash Point Method:SCC
Flash Point:90.0F,32.2C
Extinguishing Media:WATER SPRAY, DRYC HEMICAL OR CARBON DIOXIDE.
Fire Fighting Procedures:TOXIC DECOMPOSITION PRODUCT MAY FORM UNDER
FIRE CONDITION. WEAR FULL PROTECTIVE CLOTHING & FULL FACEPIECE,
POSITIVE PRESSURE, SELF-CONTAINED BREATHING APPARATUS
Unusual Fire/Explosion Hazard:KEEP AWAY FROM SPARKS & OPEN FLAMES. DO
NOT SMOKE. THE SOLVENT VAPORS ARE HEAVIER THAN AIR & MAY TRAVEL
ALONG THE FLOOR TO A SOURCE OF IGNITION & FLASHBACK.

Spill Release Procedures:ABSORB ON RAGS, SAND OR OTHER ABSORBENT
MATERIAL.

Handling and Storage Precautions:STORE PRODUCT BELOW 90F TO ENSURE
PRODUCT VISCOSITY. DO NOT STORE IN AREA WHERE VAPORS MAY CONTACT
SOURCES OF HEAT, SPARKS OR OPEN FLAMES.
Other Precautions:EMPTY CONTAINERS, CONTAMINATED CLOTHING AND CLEANING
MATERIALS, ETC. SHOULD BE CONSIDERED HAZARDOUS UNTIL DECONTAMINATED
OR PROPERLY DISPOSED OF. (SEE WASTE DISPOSAL SECTION).

Respiratory Protection:RESPIRATORS WITH ORGANIC CARTRIDGES PROVIDE
ADEQUATE PROTECTION, WITHIN USE LIMITATIONS, FOR THE FOLLOWING
COMPONENTS IN THIS PRODUCT: BUTYL ACETATE.
Ventilation:ADEQUATE LOCAL VENTILATION SHOULD BE USED TO KEEP EXPOSURES
BELOW APPLICABLE LIMITS.
Protective Gloves:BUTYL RUBBER RECOMMENDED.
Eye Protection:CHEMICAL SPLASH GOGGLES.
Other Protective Equipment:PROTECTIVE OUTER CLOTHING SHOULD BE USED
WHERE THE POSSIBILITY OF OF BODY CONTACT EXISTS
Work Hygienic Practices:AFTER HANDLING THE PRODUCT, WASH HANDS
THOROUGHLY BEFORE LEAVING THE WORK AREA.
Supplemental Safety and Health
DO NOT SMOKE, CONSUME OR STORE FOOD OR DRINKS IN AREAS WHERE THE
PRODUCT IS HANDLED OR STORED.

HCC:F3
Solubility in Water:SLIGHT
Appearance and Odor:GREY LIQUID, MILD FRUITY ODOR.

Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH: OXIDIZING AGENTS; ACIDS; POTASSIUM TERT-BUTOXIDE.
Stability Condition to Avoid:THIS PRODUCT IS NORMALLY STABLE.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
WATER; NITROGEN OXIDES; ETHYL METHACRYLATE; METHYL ACRYLATE.
Conditions to Avoid Polymerization:THIS PRODUCT DOES NOT NORMALLY
POLYMERIZE SIGNIFICANTLY.

Waste Disposal Methods:COMPONENTS OF THIS PRODUCT MAY BE CONSIDERED
HAZARDOUS; WASTE PRODUCT MAY BE REFINED TO RECOVER PRECIOUS METAL
CONTENTS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.